Volvo XC60

Supplemental Restraining System (SRS) - - Airbags keeps producing yellow caution lights and red caution lights on dash, while displaying warnings - - Drive to workshop SRS airbag Service urgent and request OK acknowledgment. This happend onec in 2023 and atleast 4 different occurrences between January and now. With atleast two repair attempts by authorized Volvo dealership with assistance of Volvo technical support engineers.

Complaint is regarding the known A/C evaporator failure in my 2019 Volvo XC60 Inscription with approximately 60,000 miles and Volvo’s subsequent denial of goodwill assistance. Disappointing Volvo denied assistance on the grounds that we had “not been loyal enough” despite having purchased 2 new vehicles from them. Both were extensively serviced at Volvo before we moved several hours away from the nearest Volvo dealership, my vehicle remained fully maintained and exceptionally low mileage. …

Collision avoidance system has activated nearly causing a collision with an oncoming vehicle three times. On narrow rural roads it is often necessary to steer quickly to the right when an oncoming vehicle approaches out of its lane. The car activates lane-keeping and steers to left toward approaching vehicle. If there is a bush or tall grass near roadway it also suddenly brakes as well as steers into traffic. This action nearly caused a collision today. Sensors are clean, windows clean, and no…

I am writing to urge NHTSA to address the serious safety problem caused by excessively bright headlights on American roads. Many LED, HID, high-mounted, improperly aimed, and aftermarket headlights produce such intense glare that oncoming drivers can be temporarily blinded. This can make it difficult to see lane markings, pedestrians, bicyclists, animals, curves, or stopped vehicles. At highway speeds, even a few seconds of impaired vision can have devastating consequences. Technology already…

2025 Volvo XC60 Plus B5, 23,317 miles. The driver's-side exterior mirror changes position without driver command, creating a safety risk due to an incorrect rearward/adjacent-lane view. This has already contributed to a close call when my wife drove the vehicle without realizing the mirror had changed from its previously set position. The issue is movement of the mirror glass within the housing, NOT the power-folding mechanism, which operates normally. When the vehicle is unlocked, the…

I purchased a 2025 Volvo XC60 new. It has 18,000 miles on the car. The tires were on the vehicle when purchased. The tires are Pirelli 255/40 RZ1 102 V Mts. DOT IXB RM 582P 1424. The front driver side tire has huge chucks of rubber missing on the tread. This issue is getting worse over time. I purchase a new tire and was told that Pirelli may reimburse me for the tire. This tire is a safety hazard. Volvo is aware of this issue however, they contiue to sell vehicles with know issues.

This has happened multiple times, confirmed by the dealer that it is a know issue with no fix. While driving down the road, the digital dashboard goes completely blank. No speedometer, no fuel guage, nothing. Very dangerous when driving to not know the speed that you are travelling. Also, all audio cuts out - no blinker signal sounds, no radio, etc. Less concerning is the infotainment system going completely black and silent as well - radio, maps, climate control. There have been multiple…

The air conditioning system in my 2021 Volvo XC60 failed, blowing hot air instead of cold. A Volvo dealer diagnosed the cause as a failed A/C evaporator core and quoted $7,800 to replace it. Volvo Cars North America has declined to provide any goodwill assistance despite this being a widely reported failure across multiple Volvo models (S60, S90, V60, XC60, XC90) at similar mileage/age, and despite Volvo having issued a running design change (a resistor harness, part no. 32241228) intended to…

While stopped at a light behind several cars with my foot firmly on the brake, the car started to move forward and could not be stopped. My foot was on the brake the entire time. The car advanced into the rear end of a pickup truck stopped in front of me. It was as though the car was fighting me as the car could not be stopped. Beyond the damage done to my car and the truck in front of me, this could have resulted in the injury of a person should someone have attempted to walk in front of my…

The A/C evaporator core on my 2021 Volvo XC60 suffered a premature structural failure, creating an immediate and severe safety hazard while driving. The component failed precisely five weeks after the Certified Pre-Owned (CPO) warranty wrapper expired. An authorized Volvo dealership service department formally inspected the vehicle and verified an active, heavy refrigerant leak utilizing UV filter video diagnostics. This component defect directly compromises vehicle safety in two distinct…