Toyota Corolla Cross

2022 Toyota Corolla Cross AWD – repeat direct fuel injector failure within 14 months / 15,500 miles. 1) Aug 22, 2025 (29,990 mi): Cylinder 4 direct injector failed. Toyota dealer replaced it under warranty and rebuilt the other three injectors. 2) Aug 26, 2025: Strong fuel smell inside the cabin, traced to injector gaskets. All four gaskets were replaced. 3) Oct 17, 2026 (45,500 mi): Cylinder 1 injector, one of the three rebuilt in Aug 2025, failed while driving. Dealer diagnosed a leaking…

The contact owns a 2024 Toyota Corolla. The contact stated that while driving 40 MPH, the bumper side quarter panel became loosened. The failure was a recurring failure. The contact used duct tape to secure the part while driving. The dealer was contacted but offered no assistance. The failure mileage was approximately 41,000.

Component: Multimedia display and connected-services software. Since September 2024, a pop-up has appeared on the center screen about every 7-10 minutes while driving: “Enter 6-digit PIN,” with “Reset PIN?” and a grayed-out “Submit” button. I have never set or used a PIN. The vehicle is available for inspection. Safety risk: The pop-up takes over the screen and hides navigation while the vehicle is moving. It occurs with both Apple CarPlay and Android Auto, which points to the vehicle’s…

The contact owns a 2022 Toyota Corolla Cross. The contact stated that on several occasions while the vehicle was parked, the rear door latches detached while opening the doors. The manufacturer was made aware of the failure by telephone. The contact was concerned that the failure posed a safety risk if children were inside the vehicle and the rear doors could not be opened due to the failure. The failure mileage was approximately 36,700.

Was backing up trying to park vehicle and suddenly vehicle accelerated forward on his own causing an accident (hit a pole). Smoke started coming out of the hood.

Vehicle: 2023 Toyota Corolla Cross Mileage: Approximately 45,000 miles Relevant Toyota Bulletin: T-SB-0020-23 Rev1 Description of Safety Concern: My 2023 Toyota Corolla Cross experienced a serious safety-related malfunction involving the automatic engine Stop and Start system. While stopped in traffic with the windshield wipers operating, the engine failed to restart automatically when I attempted to proceed. This left the vehicle temporarily unable to move as expected and required me to…

The contact owns a 2023 Toyota Corolla. The contact stated that while the vehicle was unoccupied and parked in the driveway, the vehicle caught fire. The fire originated from the engine bayapproximately five minutes after the vehicle was started. The fire department extinguished the flames and determined that the source of the fire was the battery. Both the manufacturer and the dealer were notified of the failure. The failure mileage was 80,000.

back external door handles break within a week of each other, car is quite new and has not been in a collision nor had anything fallen on the handles. Access of the back seat is difficult for this 4 door car, child too young to sit in front, so he has to sit in the back. If child needs immediate assistance, direct entry through the back doors is challenging without handles

The driver’s side A pillar that houses the airbag is not flush with the headliner. There is a gap in the upper section of the A pillar. This gap causes a distraction while driving because the gap is directly in front of the driver’s view. I took the vehicle to the Toyota of Corona dealer in Corona, CA to have the A pillar gap fixed so it is flush and not a distraction while driving. I was provided a video made by the technician of his inspection. In the video the technician acknowledged the gap…

I was driving on the XXX freeway going towards [XXX] and my sunroof exploded while I was driving. The sunroof was shattered. I was maybe 15 to 20 minutes from my exit. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)