GMC R2500 Suburban

CONSUMER'S VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE THAT WAS TRAVELING AT 30 MPH. PASSENGER'S SIDE SEAT BELT CAME UNBOLTED FROM THE FLOORBOARD. AS A RESULT, PASSENGER SUSTAINED A BACK INJURY. *AK

CONSUMER STATES THE METAL PARKING BRAKE CABLE WEARS INTO THE RUBBER BRAKE HOSE, WHICH COULD CAUSE FAILURE OF THE BRAKE HOSE AND THE REAR BRAKES, THE RUBBER BRAKE HOSE WAS ALMOST WORN TO THE POINT OF FAILURE, THE METAL PARKING BRAKE CABLE DOES HAVE A METAL SLEEVE ON IT TO PROTECT THE RUBBER HOSE, BUT THE NATURAL POSITION OF THE HOSE AND CABLE CAUSES THE SLEEVE TO NOT LINE UP IN THE DESIRED POSITION. *TT

CONSUMER RAISED HOOD; ATTEMPTED TO START VEHICLE, AFTER VEHICLE WOULD NOT START, DOUGLAS BATTERY SUDDENLY BLEW UP, CONSUMER WAS INJURED. *AK *TT

I BELIEVE THE SUBURBAN SERIES VEHICLES HAVE A DESIGN DEFECT IN THE BRAKE SYSTEM BECAUSE THE REAR BRAKE HOSE(FROM THE BODY TO A CONNECTOR ABOVE THE DIFFERENTIAL) IS USED AS A SUPPORT FOR THE PARKING BRAKE CABLE. THE STRONGER, HEAVIER PARKING BRAKE CABLE RUBS ON THE RUBBER BRAKE HOSE, CAUSING THE RUBBER HOSE TO FAIL. THE PARKING BRAKE CABLE DOES HAVE A 2INCH METAL SLEEVE OVER IT NEAR WHERE THE HOSE AND CABLE RUB. HOWEVER, THIS SLEEVE IS NOT LOCATED WHERE THE NATURAL LAY OF THE HOSE/CABLE IS. …

UPPER BALL JOINTS WERE REPLACED 9/25/99 BY SUSPENSION PLUS IN SAN DIEGO USING MCQUAY NORRIS PARTS.. ON OR ABOUT 11/04/2000 THE VEHICLE WAS TURNING AT LOW SPEED LEFT TURN INTO A PARKING LOT WHEN THE RIGHT FRONT WHEEL COLLAPSED UNDER THE FRONT END. SUBSEQUENT REPAIR ACTION DETERMINED THAT THE REPLACED UPPER BALL JOINT ASSEMBLY HAD FAILED BY SEPARATION OF THE BALL JOINT RETAINER ASSEMBLY FROM THE BALL JOINT. THE FAILURE OCCURRED AFTER 9,000 MILES OF OPERATION. WE HAVE THE FAILED PART.*AK

DRIVING ON HIGHWAY. THE VEHICLE STARTED RACING. COULD NOT STOP. PUT IN NUETRAL,ENGINE RACING. SHUT ENGINE . LATER FOUND THAT THE HOOK FROM SERVO HAD RUSTED AND BROKEN OFF AND THE BAR ATTACHED TO THE THROTTLE HAD GOTTEN STUCK IN THE THROTTLE. THIS HOOK SHOULD NOT BE OF A MATERIAL THAT CAN RUST & BREAK OFF LIKE THAT. ALSO I HAVE LOOKED INTO THE SERVICE MANUAL & THERE IS NO MENTION OF SERVICE TO THAT PART ATALL.WHY WILL THE MECHANIC EVEN LOOK AT THAT PART IF THERE IS NO MENTION FOR MAINTENANCE TO…

LEFT REAR TIRE FELL OFF WHILE DRIVING, TIRE ROLLED AT A HIGH SPEED ONTO INCOMING TRAFFIC, VEHICLE WAS NOT ABLE TO STOP RIGHT AWAY AND DRUM WAS DRAGGED 192 FEET, ONCE VEHICLE STOPPED IT WAS UP ON SIDEWALK, POSSIBLY RELATED TO LUG NUT FAILURE, REPAIR INCLUDED NEW LOCKS FOR THE LUG NUTS. *JB

FRAME OF SEAT BACK SNAPPED WHEN DRIVER ENTERED VEHICLE AND GOT INTO SEAT. *AK

RECALL 93V187000, WAS PERFORMED, SEAT BOLTS BROKE 2 TIMES AFTER THAT, AND 3RD TIME CONSUMER HAD TO REPLACE WHOLE SEAT FRAME. *AK

CONSUMER RECEIVED RECALL NOTIFICATION REGARDING THE ABS SYSTEM, THE VEHICLE HAS EXPERIENCED CONTINUED PROBLEMS RELATED TO THE ABS SYSTEM PRIOR TO NOTIFICATION, DEALER REFUSED RECALL REPAIR 99041, THE VEHICLE'S VIN # DID NOT QUALIFY FOR REPAIRS. *MJS