GMC R1500 Suburban

GM ISSUED A RECALL FOR 2000-2001 SUBURBANS TO REPAIR A FAULTY ELECTRIC WIRE ON THE FUEL PUMP WHICH CAUSED STALLING. I HAD TO PAY $85 DIRECTLY AND APPROXIMATELY $500 IN CONSEQUENTIAL DAMAGE TO REPAIR THE EXACT SAME WIRE WHICH FAILED IN MY 1991 GMC SUBURBAN. GM REFUSED TO REIMBURSE DIRECT COSTS OF REPAIR. THIS WAS A VERY DANGEROUS CONDITION AS IT COULD OCCUR WHILE DRIVING, ENTAILING COMPLETE LOSS OF POWER STEERING AND POWER BRAKES.*AK

WHILE DRIVING A LOUD NOISE WAS HEARD COMING FROM THE FRONT. CONSUMER PULLED OVER , AND SAW THAT THE PASSENGER'S SIDE REAR TIRE TREAD SEPARATED FROM THE VEHICLE. CONSUMER CHANGED THE TIRE, AND DROVE VEHICLE TO THE DEALER FOR INSPECTION. FIRESTONE, FR480, P235/75R15, #DOT NUMBER HDHL1PA066.*AK

CONSUMER'S VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE THAT WAS TRAVELING AT 30 MPH. PASSENGER'S SIDE SEAT BELT CAME UNBOLTED FROM THE FLOORBOARD. AS A RESULT, PASSENGER SUSTAINED A BACK INJURY. *AK

THE WINDSHIELD WIPERS SPORADICALLY WORKS CAUSING LITTLE TO NO VISIBILITY. *NLM

CONSUMER STATES THE METAL PARKING BRAKE CABLE WEARS INTO THE RUBBER BRAKE HOSE, WHICH COULD CAUSE FAILURE OF THE BRAKE HOSE AND THE REAR BRAKES, THE RUBBER BRAKE HOSE WAS ALMOST WORN TO THE POINT OF FAILURE, THE METAL PARKING BRAKE CABLE DOES HAVE A METAL SLEEVE ON IT TO PROTECT THE RUBBER HOSE, BUT THE NATURAL POSITION OF THE HOSE AND CABLE CAUSES THE SLEEVE TO NOT LINE UP IN THE DESIRED POSITION. *TT

CONSUMER RAISED HOOD; ATTEMPTED TO START VEHICLE, AFTER VEHICLE WOULD NOT START, DOUGLAS BATTERY SUDDENLY BLEW UP, CONSUMER WAS INJURED. *AK *TT

I BELIEVE THE SUBURBAN SERIES VEHICLES HAVE A DESIGN DEFECT IN THE BRAKE SYSTEM BECAUSE THE REAR BRAKE HOSE(FROM THE BODY TO A CONNECTOR ABOVE THE DIFFERENTIAL) IS USED AS A SUPPORT FOR THE PARKING BRAKE CABLE. THE STRONGER, HEAVIER PARKING BRAKE CABLE RUBS ON THE RUBBER BRAKE HOSE, CAUSING THE RUBBER HOSE TO FAIL. THE PARKING BRAKE CABLE DOES HAVE A 2INCH METAL SLEEVE OVER IT NEAR WHERE THE HOSE AND CABLE RUB. HOWEVER, THIS SLEEVE IS NOT LOCATED WHERE THE NATURAL LAY OF THE HOSE/CABLE IS. …

CONSUMER FEELS THAT ENGINE FOR VEHICLE IS CRACKED. PLEASE PROVIDE FURTHER DETAILS.*AK

UPPER BALL JOINTS WERE REPLACED 9/25/99 BY SUSPENSION PLUS IN SAN DIEGO USING MCQUAY NORRIS PARTS.. ON OR ABOUT 11/04/2000 THE VEHICLE WAS TURNING AT LOW SPEED LEFT TURN INTO A PARKING LOT WHEN THE RIGHT FRONT WHEEL COLLAPSED UNDER THE FRONT END. SUBSEQUENT REPAIR ACTION DETERMINED THAT THE REPLACED UPPER BALL JOINT ASSEMBLY HAD FAILED BY SEPARATION OF THE BALL JOINT RETAINER ASSEMBLY FROM THE BALL JOINT. THE FAILURE OCCURRED AFTER 9,000 MILES OF OPERATION. WE HAVE THE FAILED PART.*AK

DRIVING ON HIGHWAY. THE VEHICLE STARTED RACING. COULD NOT STOP. PUT IN NUETRAL,ENGINE RACING. SHUT ENGINE . LATER FOUND THAT THE HOOK FROM SERVO HAD RUSTED AND BROKEN OFF AND THE BAR ATTACHED TO THE THROTTLE HAD GOTTEN STUCK IN THE THROTTLE. THIS HOOK SHOULD NOT BE OF A MATERIAL THAT CAN RUST & BREAK OFF LIKE THAT. ALSO I HAVE LOOKED INTO THE SERVICE MANUAL & THERE IS NO MENTION OF SERVICE TO THAT PART ATALL.WHY WILL THE MECHANIC EVEN LOOK AT THAT PART IF THERE IS NO MENTION FOR MAINTENANCE TO…