Ford Transit Connect

Was driving on the highway. Thought there was a smell of something burning. Stopped didn't see anything. When I arrived at my location the smell was much stronger. When I stopped I saw smoke and fire coming from the left front tire. Fire Department was called because the vehicle was parked next to a building. I used three fire extinguishers to put the fire out. The fire department arrived and put water on the area to lower the heat. It turns out the ABS system malfunctioned locking up the right…

My husband was driving the vehicle and I was the passenger. We got on the highway and were going 67 mph when we smelled something burning. The vehicle speed dropped from 67 mph to 30 mph. No warning lights on the dashboard alerted to anything. We got off the highway and to a place of safety. We got out of the vehicle and both front rotors were glowing red and flames were coming out from behind the driver's side wheel. We had to use an ABC fire extinguisher (which we had in the vehicle) on both…

While driving down the road the ABS brakes (front driver and passenger rear) started tightening up then they temporarily released for a few miles. Then started tightening up again it continued to tighted and not release until it was completely locked down. Immediately pulled off road and brakes visibly caught on fire and damaged all components in the wheels. This could have been a dangerous situation for myself or others on the road if it hadnt occured at a lower speed. This scenario has also…

On going problem that's getting worse and have totally stopped driving the van. Transmission Severe Slipping, harsh and hard shifting, abrupt Highway deceleration & violent downshift while on the Hwy. Pauses sometimes to accelerate from a stop and sometimes lunges forward. Occasional thumping sound when driving at a consistent speed. Has not been inspected yet at the Ford dealership as we are trying to make an appointment. No warning lights or messages have come on ever. Have discovered that…

The contact owns a 2020 Ford Transit Connect. The contact stated that while attempting to pull into a parking lot, the brakes locked up. There was no warning light illuminated. The contact stated that several attempts were made to forcefully engage and unlock the brakes. After restarting the vehicle, there was a burning odor coming from the brakes. The contact stated that the brakes slowly released after the vehicle was turned off. The vehicle was taken to the dealer, where it was diagnosed…

Ford is using a heavy, wax inside the bottom of the door/side panels. When the weather gets hot, this wax softens, and runs downward, and solidifies directly over the tiny weep holes at the bottom of the doors, trapping rain and wash water inside the door panels. I Always have to clear the weep holes over and over after a carwash or rain storm. The windshield Leakes water and drips on the dashboard. I believe the trapped musty water and leaks cause dampness creating several critical safety,…

The contact owns a 2017 Ford Transit Connect. The contact stated that while the vehicle was in reverse, the rear-view camera displayed a blank screen with the message Camera Unavailable. The contact stated that the VIN was not included in NHTSA Campaign Number: 25V572000 (Back Over Prevention). The local dealer was contacted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 92,000. EVOQ N N N N V N N

Intermittent Electronic issues are: 1) Rear view backup camera malfunction. Works sporadically. Camera some times clear as bell, and stays on when in drive moving forward. Other days camera fails to blue screen, then turns gray with message that camera is unavailable, contact dealership. Defect is not currently not listed for this vehicle as a recall. Definite safety hazard with camera staying on when vehicle is in drive and moving forward. 2) Auto start, stop feature was functioning when…

On XXX at 1820 hrs CST I was traveling westbound on HWY XXX between [XXX] and Central [XXX] [XXX]. The weather was sunny, temp 88 degrees. As I was driving between 60 and 65 MPH with cars in front as well as behind me I heard a very loud “explosion” type noise. It was loud and quite scary and unexpected. The car then became very loud and windy. I was able to keep the car on the road, when I looked up I realized the panoramic window on the roof was mostly gone and damaged as well as the shade…

I am writing to report a serious safety concern involving our 2023 Ford Transit Connect (VIN [XXX]) van that resulted in an unintended vehicle movement and collision. While the incident resulted in only minor property damage and a minor injury, we believe the circumstances warrant review due to the potential for a much more severe outcome. The vehicle had been exhibiting operational issues prior to the incident. Employees reported that it was running and shifting noticeably rough and, after…