Ford Econoline Super Duty

This vehicle was made by Ford as a partially complete vehicle and converted to 4 wheel drive by Quigley Motor Company Inc. The Quigley torque arms installed appear to commonly fail from some of the earlier years and a design change has been made (from C-channel arms to tubular). The design and construction of the C-channel torque arm (connecting the front axle to the frame of the vehicle) is prone to failure from low cycle fatigue near the welds. Upon failure, the structural integrity of the…

VAN IS LEAKING FUEL FROM A CRACK WHERE IT CONTACTS THE FRAME MEMBER. THIS VAN WAS SUBJECT TO A RECALL BEGINNING APRIL 19, 2001. I DID NOT OWN THE VEHICLE AT THAT TIME, BUT APPARENTLY VEHICLE WAS NOT LEAKING SO IT WAS NOT FIXED. I DO NOT HAVE THE RECALL NUMBER. I OBTAINED THIS INFORMATION FROM A VIN LOOK UP AT HTTPS://DRIVING-TESTS.ORG/VIN-DECODER/ VEHICLE ONLY LEAKS FUEL WHEN FILLING UP AT THE GAS STATION. ONCE I STOP FILLING UP, THE LEAKING WILL DRIP, DRIP, DRIP UNTIL IT STOPS AND I CAN…

TL* THE CONTACT OWNS A 1999 FORD ECONO RV S-DUTY EQUIPPED WITH A SAMSUNG MICROWAVE, MODEL MR5493G. THE CONTACT STATED THAT THE FAILURE WAS IDENTICAL TO OVEN CIRCUIT RECALL NUMBER: 03E044400. A NEIGHBOR ADVISED THE CONTACT THAT THE RV WAS ON FIRE. THE CONTACT OBSERVED THAT THE MICROWAVE CAUSED THE FIRE AND SHE EXTINGUISHED IT WITHOUT NOTIFYING THE FIRE DEPARTMENT. THE CONTACT SUSTAINED AN EXTENSIVE BURN ON HER LEG, BUT DID NOT SEEK MEDICAL ATTENTION. SAMSUNG ADVISED HER THAT THEY HAD NO PARTS TO…

IF YOU LOWER THE STEERING WHEEL FOR COMFORTABLE STEERING THE BLINKERS AND BRAKES AND SEVERAL OTHER ELECTRICAL COMPONENTS STOP WORKING. WHILE IN MOTION OR STOPPED.IF YOU RAISE THE STEERING WHEEL LL THE WAY BACK UP THE THINGS START WORKING AGAIN.

VAN IS LEAKING FUEL WHEN I ATTEMPT TO FILL THE TANK.

BLEW A SPARK PLUG OUT OF ENGINE 2ND ONE THAT HAS HAPPEN AND IT HAPPENS ALL THE TIME WITH THIS ENGINE

WAS TRAVELING ON RT 80 NEAR EXIT 123 IN PENNSYLVANIA ON STRAIGHT ROAD, AT 65 MPH, TEMPERATURE OF 75 DEGREES, DRY, SUNNY DAY. WE HEARD A LOUD BOOM. THE INSIDE REAR TIRE (DRIVER SIDE) HAD BLOWN. IT APPEARED THAT THE SIDEWALL (FACING OUT) HAD FAILED. THE SIDEWALL SEPARATED ALONG A STRAIGHT LINE FROM THE WHEEL TO THE TREAD. ALSO, IN THAT AREA ABOUT 10 INCHES OF TREAD WAS STARTING TO SEPARATE ON THAT SIDE OF THE TIRE - THE TREAD SEPARATION WAS 'CENTERED' ON THAT SIDEWALL FAILURE. FORTUNATELY WE…

1997 FORD ECONOLINE. CONSUMER WRITES IN REGARDS TO TIRE ISSUES AND REPAIR REIMBURSEMENT.* LD THE CONSUMER DISCOVERED THE TIRES ON HER VEHICLE WERE RECALLED. HOWEVER, SHE WAS NEVER NOTIFIED. RECALL #12T007000. *JB

TL* THE CONTACT OWNS A 1999 FORD ECONOLINE. THE CONTACT STATED THAT THERE WAS A STRONG ODOR COMING FROM THE VEHICLE. THE CONTACT DISCOVERED THAT THERE WAS PROPANE LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE MAIN PROPANE TANK NEEDED TO BE LIFTED OFF THE SPRING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000. UPDATED 4/7/15*CN THE CONSUMER STATED THE MANUFACTURER PUT PROPANE/LIPI GAS…

TL* THE CONTACT OWN A 1999 FORD ECONOLINE 350 EQUIPPED WITH KELLY TIRES, TIRE LINE: SAFARI LT, TIRE SIZE LT23585R16. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, A LOUD BANGING NOISE AND THE SOUND OF METAL BEING DRAGGED ON THE GROUND WAS HEARD FROM OUTSIDE OF THE VEHICLE. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT NOTICED THAT THE FRONT PASSENGER'S SIDE TIRE EXPLODED. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE DEFECTIVE TIRE HAD NOT BEEN REPLACED.THE MANUFACTURER HAD NOT…