Ford E-250 Econoline

We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder…

Random Acceleration (Gas Pedal) when started from a cold start. When foot was not on any brake or gas pedal, van started to accelerate as if I had my foot on the gas pedal.

seat belt not pulling out e40d trans starts out going in 3ed gear

This vehicle was made by Ford as a partially complete vehicle and converted to 4 wheel drive by Quigley Motor Company Inc. The Quigley torque arms installed appear to commonly fail from some of the earlier years and a design change has been made (from C-channel arms to tubular). The design and construction of the C-channel torque arm (connecting the front axle to the frame of the vehicle) is prone to failure from low cycle fatigue near the welds. Upon failure, the structural integrity of the…

VAN IS LEAKING FUEL FROM A CRACK WHERE IT CONTACTS THE FRAME MEMBER. THIS VAN WAS SUBJECT TO A RECALL BEGINNING APRIL 19, 2001. I DID NOT OWN THE VEHICLE AT THAT TIME, BUT APPARENTLY VEHICLE WAS NOT LEAKING SO IT WAS NOT FIXED. I DO NOT HAVE THE RECALL NUMBER. I OBTAINED THIS INFORMATION FROM A VIN LOOK UP AT HTTPS://DRIVING-TESTS.ORG/VIN-DECODER/ VEHICLE ONLY LEAKS FUEL WHEN FILLING UP AT THE GAS STATION. ONCE I STOP FILLING UP, THE LEAKING WILL DRIP, DRIP, DRIP UNTIL IT STOPS AND I CAN…

BOTH FRONT TIRES MERELY DEVELOPED TREAD BULGES , LESS THAN 15K MILES, NEVER HAD A FLAT, BEEN OVERLOADED ,OVERINFLATED , ECT.. THEY JUST BECAME VERY POOR DRIVING AND VIBRATED BADLY TO FIND THEY BOTH HAVE BULGES IN THE TREAD. THEY SEEMED FINE ABOUT TWO WEEKS AGO AND WHEN I WENT TO DRIVE IT A COUPLE DAYS AGO THE PROBLEM BECAME APPARENT. *TR

REAR ABS MODULE FAILED. CAUSING OVER PRESSURIZATION OF FRONT BRAKES RESULTING IN PASSENGER SIDE BRAKE HOSE SEPARATION. SO NO REAR OR FRONT BRAKES! THANK GOD IT HAPPENED NEAR MY DRIVEWAY OTHERWISE PEOPLE COULD DIE. I HAD JUST REENTERED DRIVERS SEAT AND RELEASED PARKING BRAKE AND ENGAGED BRAKE PEDAL WITH 1 FOOT. VEHICLE WAS STATIONARY POINTED IN A STRAIGHT LINE.

TL* THE CONTACT OWNS A 1999 FORD ECONO RV S-DUTY EQUIPPED WITH A SAMSUNG MICROWAVE, MODEL MR5493G. THE CONTACT STATED THAT THE FAILURE WAS IDENTICAL TO OVEN CIRCUIT RECALL NUMBER: 03E044400. A NEIGHBOR ADVISED THE CONTACT THAT THE RV WAS ON FIRE. THE CONTACT OBSERVED THAT THE MICROWAVE CAUSED THE FIRE AND SHE EXTINGUISHED IT WITHOUT NOTIFYING THE FIRE DEPARTMENT. THE CONTACT SUSTAINED AN EXTENSIVE BURN ON HER LEG, BUT DID NOT SEEK MEDICAL ATTENTION. SAMSUNG ADVISED HER THAT THEY HAD NO PARTS TO…

LEFT HOUSE FOR VACATION, GOT 75 MILES AWAY AT 60 MPH ON THE FREEWAY, AND ENGINE STARTED MAKING A POPPING SOUND. PULLED OFF ROAD AND CALLED A NEARBY MOBILE REPAIR COMPANY. THEY SENT OUT A MECHANIC, HE DIAGNOSED A BLOWN OUT SPARK PLUG, AND SAID THIS WAS COMMON FOR THE FORD V-10. MADE IT TO HIS SHOP, AND THAT'S WHERE IT SITS. ESTIMATES ARE OVER $4000 TO REPAIR.

CAN'T SWITCH FROM FRONT AUX. GAS TANK TO REAR MAIN GAS TANK, AND GAS GAUGE NOT FUNCTIONING. VERY SLOW FILLING AND NOTICED GAS COMING OUT OF FILLER SPOUT. THIS VAN IS NEW TO ME AND JUST NOTICED THESE PROBLEMS THIS MONTH MAY 1/2017