Kia EV9

In July 2024, approximately two months after purchasing the vehicle new in May 2024, a significant spiderweb-shaped crack developed in the front illuminated grille and fascia assembly. The vehicle had approximately 300 miles on the odometer and the damage was discovered during a routine hand wash. The vehicle had only been driven under normal roadway conditions in the Corpus Christi, Texas area with no collisions, accidents, or known abnormal impacts. This exposed acrylic-style front fascia…

On my 2024 Kia EV9 GT-Line, the front illuminated digital pattern acrylic/plastic grill panel suffered a catastrophic structural failure, resulting in a complete blowout and puncture hole under normal driving conditions. The panel fractured and shattered completely while driving on standard paved roads, with zero history of front-end collisions, low-speed impacts, or road debris strikes. This indicates a severe material strength, thermal stress, or structural design defect where the acrylic…

On September 10, 2026, while driving my Kia EV9 on a public roadway, I experienced a suspected unintended and excessive activation of the vehicle's collision-avoidance/automatic emergency braking system. I was traveling straight in my lane when another vehicle approached from the right side and crossed/moved into the roadway ahead. The other vehicle continued moving away from my immediate path; however, my EV9 suddenly applied substantial braking without me commanding that degree of braking.…

Three of four original-equipment Kumho Crugen HP71 EV tires, size 255/60R19, on my 2025 Kia EV9 (VIN [XXX], 12,786 miles at failure) are out of round - a manufacturing defect present since the tires left the factory. On [XXX], Lee Johnson Kia in Kirkland, WA measured the rear-passenger tire at 37 lbs of road force against a 7-lb spec - more than five times the allowable limit. After dismount and remount it still measured 23 lbs. The technician documented the tire as out of round and requiring…

My 205 EV9 Wind with 24500 Miles left me stranded, the standard battery simbol that in ICE cards refers to the alternator, came on, I tried to get to the dealer about 20 miles in the way home, less that 3 miles after that the car lost power with just enough to move to the shoulder, I stopped, power the car off and tried turning it back on, no success, but this time I had enough power to park in a safer position. I took the vehicle on a tow truck that was called by the Kia Assistance.

Beginning sometime after purchase, our 2024 Kia EV9 (VIN: [XXX]) developed a recurring failure of the multimedia display system (head unit). The screen goes completely dark after approximately 5 minutes of drive time and only restores after a full vehicle restart. This failure occurred approximately 10 to 14 times before we brought the vehicle in for service. Critically, when the multimedia screen goes dark, the rearview camera display is also rendered completely unavailable. As the rearview…

The contact owns a 2024 Kia EV9. The contact stated that while attempting to release the rear seat belt to install a child safety seat, a significant amount of effort was required. The contact stated that after struggling with the seat belts over several months of use, the seat belt became fully jammed and no longer was able to be extended. The dealer was notified of the failure on several occasions. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage…

When I started the car up, I noticed a little bit of chattering on the brake pedal, which seemed very unusual. I drove the car forward a little bit and then all of a sudden, all these lights displays and stop vehicle and check brake system now message showed up. The car was very sluggish to drive and had almost no brake pressure. I was able to drive it out of the parking lot (slowly and carefully). When I called a tow truck, I left the vehicle off for about 20 or 30 minutes, and then when I…

The infotainment screen, including backup camera views, randomly glitches and then goes completely dark with no ability to view anything on the screen. The screen has been reset and software reloaded, but the glitch continues. Next, the screen was replaced but the glitch continues. This has been occurring since the beginning of June 2026.

For several weeks the car has felt out of balance and I had it in the shop once to be balanced. The balance felt it lasted a very short time. I took the car in today to be checked out and the passenger rear tire couldn’t hold a balance. Mechanic removed tire and the interior sound deadening foam had detached on greater than 50% of the diameter of the tire. This has been widely commented on as a common failure mode for these Hankook tires on EV9 vehicles. I wanted the remaining tires inspected…